使之降低蒸汽消耗，降低生产成本。
The steam consumption is reduced, the production cost is decreased.
第三，降低蒸汽疏水阀自身的蒸汽消耗量。
Third, reduce the consumption of steam trap their own steam.
吨成品蒸汽消耗约1。
在额定工况下运转时，机组蒸汽消耗率约为0。
本发明可以简化操作过程，减少蒸汽消耗和操作费用。
The invention can simplify the operation process and reduce the steam consumption and the operation cost.
减少燃料气、电耗和蒸汽消耗是降低装置能耗的关键。
Reducing the consumption of fuel gas, electricity and steam is the key to reducing the energy consumption of the unit.
改进后蒸发器的蒸发效率显著提高，蒸汽消耗明显降低。
The evaporation efficiency of the evaporator, after modified, has been obviously improved and the steam consumption greatly reduced.
采用结构填料脱臭塔或改造板式脱臭塔都可以降低蒸汽消耗量。
Using structured packing column or modification oft ray column can reduce the steam consumption.
通过对隔膜蒸发进行工艺设备改造，使蒸发的蒸汽消耗明显降低。
The steam consumption in evaporation has been obviously reduced by way of innovating the process and device in diaphragm evaporation.
分析了液碱蒸发装置结盐对蒸发传热系数、生产能力和蒸汽消耗的影响。
The influences of salt scale on heat transfer coefficient, production capacity and steam consumption in the evaporation of liquid caustic soda are analyzed.
牵伸机的蒸汽冷凝疏水系统的优劣决定了辊筒表面温度的高低和蒸汽消耗量的大小。
The high or low of surface temperature of roller and the big or small of steam wastage is decided by the good or bad of steam condensation and draining system of stretch machine.
在变换反应过程中要消耗大量蒸汽，其蒸汽消耗量占合成氨生产总蒸汽消耗量的30%以上。
A large amount of steam will be consumed in the course of its shift reaction, and its consumption of steam is more than 30% of the amount steam of synthetic ammonia production.
目前蒸汽消耗占木糖生产成本的50%左右，如何降低蒸汽单耗是实现降本的主要工作之一。
Steam consumption accounts for about 50% of the total cost. Therefore, finding a method to reduce the unit consumption of steam is one of the focuses of our work.
本文的目的是设计一套吸收式热泵回收这部分热量，用来预热盐水，达到降低蒸汽消耗的目的。
A set of absorption heat pump is designed to recycle these heat for preheating brine and reduce the steam consumption.
文中还以降低蒸汽消耗为目的，通过理论分析和计算，提出了控制系统的改进方向和控制方案。
Aimed at reducing the consumption of the steam, this paper also puts forward a design and the improving direction of the control system through analysis and computation.
论述了TC 201空气压缩机组性能运行状况和工艺参数优化。使之降低蒸汽消耗，降低生产成本。
The operation condition and technological parameters optimization and adjustment of TC201 air compressor units are introduced. The steam consumption is reduced, the production cost is decreased.
本文讨论了直接加热器在糖厂使用对糖厂热力经济的影响，介绍了直接加热过程蒸汽消耗的数量分析方法和计算公式。
In this paper the effect of using direct heater on heat economy of sugar factories is discussed, also the quantity analysis method and calculation equations for vapor consumption are introduced.
考察了理论板数、进料位置等对蒸汽消耗量及废水排放的影响；研究了增加侧采工艺和热泵回收工艺对节能减排的促进作用。
Promotion of added side withdrawing technology and heat pump recovery process for energy conservation and emission reduction of the prefractionator is made.
溶出作为该氧化铝生产工艺的关键工序，不仅占整个氧化铝生产蒸汽消耗的50%以上，而且是影响氧化铝工艺指标的关键工序。
The dissolution process is the key to the process, which not only consumes more than 50% steam of the whole process, but also has an important factor to determine the quality of parameters of process.
最后一步是将蒸汽引入气缸，使得活塞前后推动，从而提高了发动机的速度，降低了燃料消耗。
The final step came when steam was introduced into the cylinder to drive the piston backward as well as forward, thereby increasing the speed of the engine and cutting its fuel consumption.
利用此类蒸汽可能代价不菲，因为这不仅要消耗额外的建筑材料，而且要求所用的建材更为牢固以经受更高的压力和温度。
Tapping this steam would be expensive, since it would require not only extra building materials, but also more durable ones, to cope with the higher pressures and temperatures.
采用溶剂的方法比加热，抽取，然后再利用生产蒸汽的水资源这一处理过程要消耗更少的能量。
The solvent approach requires less energy than heating, pumping, and recycling water for steam.
蒸汽代表著最好的解决办法，可以减到最少的消耗成本，免除清洁剂和消毒剂。
Steam represents the best solution as it allows to cut to the bare minimum if not to get rid of any detergent or disinfectant.
本文还对热泵干燥、电加热干燥、蒸汽加热干燥的一次能源消耗和能源费用进行了比较和经济评价。
The primary energy consumption and the energy cost of the heat pump dryer are compared with those of electrical heating dryer and steam-heating dryer and their economic evaluations are carried out.
本文通过对某碱厂蒸汽加热系统的能量消耗进行全局的综合能量平衡分析，指出其存在的问题和节能降耗改造的措施。
This paper points out problems on energy consumption and gives some measures on energy conservation, which result from energy balance analysis of steam heat exchange system of an alkali factory.
介绍了聚氯乙烯树脂生产过程中干燥工段空气加热器消耗蒸汽的情况。
The evaporation consumption status of air heater in drying section in resin production was introduced.
在溴法合成香兰素新工艺中，用水蒸汽蒸馏法回收萃余相中的溴，降低了溴的消耗定额。
In the new process of synthesis of vanillin with bromine, the bromine in the wastewater is retrieved by steam distillation. As a result, the bromine consumption is reduced.
动力(煤、蒸汽、水、电)消耗、热力站的设计及设备维修管理是影响供热成本的因素。
The consumption of power including coal, steam, water and electricity, the design of substation and the equipment maintenance management are factors influencing heat-supply cost.
对两班制及少蒸汽运行工况下的热应力和寿命消耗进行了若干方案的计算；
The thermal stress and life expenditure of the steam turbine rotors in various starting conditions are given.
山东铝业公司是能源消耗大户，也是蒸汽耗用大户。
SALCO is a big consumer of energy, and it is also a big steam consumer.
应用推荐